Product ID:YELLOW EPOXY PRIMER 20P1-10
MSDS Date:05/26/1994
FSC:8030
NIIN:00-062-8449
Kit Part:Y
MSDS Number: BVYFX

CROWN METRO AEROSPACE COATINGS, INC

ECHELON, DONALDSON CTR
GREENVILLE, SC 29606
US

Emergency Phone: 803-277-1870

Info Phone: 803-277-1870

Preparer: ODELL

Cage: CROME

RALRUBE INC.

FARMINGTON HILLS, MI 48331 US

Telephone: 248-661-0260, FAX 248-661-3941

Cage: 6X798

CRYSTALLINE SILICA (QUARTZ)

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 0.13497%

OSHA PEL 0.1 MG/M3

ACGIH TLV: 0.1 MG/M3

STRONTIUM CHROMATE (SARA III)

CAS: 7789-06-2

RTECS: GB3240000

Fraction By Weight: 7.9844%

ACGIH TLV: 0.0005 MG/M3

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

1-METHOXY 2-PROPANOL ACETATE (VAPOR PRESSURE 3.8 MM HG @

CAS: 108-65-6

RTECS: AI8925000

Fraction By Weight: 10-20%

CYCLOHEXANONE

CAS: 108-94-1

RTECS: GW1050000

Fraction By Weight: <10%

OSHA PEL 25 PPM (SKIN)

ACGIH TLV: 25 PPM (SKIN)

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ETHYL KETONE (SARA III) (VAPOR PRESSURE 70.2 MM HG @

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 35%

OSHA PEL 200 PPM;STEL 300 PPM

ACGIH TLV: 200 PPM;STEL 300 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CADMIUM (SARA III) (IN NON-VOLATILES)

CAS: 7440-43-9

RTECS: EU9800000

Fraction By Weight: 5.7%

OSHA PEL 5MG/M3;CEIL 0.6MG/M3

ACGIH TLV: 0.01 MG/M3

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

BARIUM SULFATE (IN NON-VOLATILES) (SARA III)

CAS: 7727-43-7

RTECS: CR0600000

Fraction By Weight: 2%

OSHA PEL 5 MG/M3

ACGIH TLV: 10 MG/M3

5.0 POUNDS PER GALLON

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:ACUTE: OVEREXPOSURE BY INHALATION MAY
CAUSE IRRITATION OF RESPIRATORY TRACT, HEADACHE, DIZZINESS,AND
DROWSINESS. SKIN/EYE CONTACT: IRRITANT TO EYES & SKIN. CHRONIC
HEALTH EFFECTS: MAY AFFECT FOLLOWING ORGANS: RESPIRATORY TRACT,
KIDNEYS, REPRODUCTIVE SYSTEM, LIVER, BLOOD, CENTRAL NERVOUS SYSTEM,
CORNEAL INJURY.
Medical Cond Aggravated by Exposure:UNKNOWN AT THIS TIME

First Aid:INHALATION: REMOVE FROM EXPOSURE. EYE CONTACT: FLUSH
IMMEDIATELY WITH LARGE AMOUNTS OF RUNNING WATER FOR AT LEAST 15
MINUTES. SKIN CONTACT: REMOVE CONTAMINATED CLOTHING AND WASH SKIN
WITH SOAP AND WAT ER. INGESTION: DRINK WATER. IF NECESSARY, CONSULT
A PHYSICIAN FOR ANY OF THESE CONDITIONS.

Flash Point Method:SCC
Flash Point:26.0F,-3.3C
Lower Limits:1.10
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL, OR CARBON
DIOXIDE

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION, AVOID
BREATHING VAPORS. VENTILATE AREA AND REMOVE WITH INERT ABSORBENT
AND NON-SPARKING TOOLS. BEFORE ATTEMPTING TO CLEAN UP, SEE
INGREDIENT SECTION.

Handling and Storage Precautions:DO NOT TAKE INTERNALLY. CONTAINERS
SHOULD BE GROUNDED WHEN POURING. AVOID FREE FALL OF LIQUID IN
EXCESS OF A FEW INCHES.
Other Precautions:MAKE SURE THE DRUM IS COMPLETELY EMPTY BEFORE
ATTEMPTING TO WELD OR BRAZE. THE DRUM SHOULD BE INDUSTRIALLY
CLEANED PRIOR TO REUSE. DO NOT FLAME CUT, BRAZE OR WELD WITHOUT A
NIOSH APPROVED RESPIRATOR O R APPROPRIATE VENTILATION.

Respiratory Protection:IF GENERAL DILUTION/LOCAL EXHAUST FAILS TO
DILUTE ADEQUATELY, USE RESP PROTECTION IN ACCORD W/29CFR 1910.134,
USE NIOSH/MSHA AIR LINE TYPE RESPIRATOR/HOOD FOR ENCLOSED &
CONFINED AREA. AIR PURIFYING R ESPIRATOR MAY BE USED FOR OTHER
AREAS.
Ventilation:PROVIDE GENERAL DILUTION OR LOCAL EXHAUST VENT TO KEEP TWA
& LEL BELOW ACCEPTABLE LIMITS & REMOVE DECOMPOSITION PRODUCTS
Protective Gloves:CHEM RESISTANT GLOVES-PROLONGED/REPEATED
Eye Protection:SAFETY EYEWARE-PROTECT AGAINST SPLASH
Supplemental Safety and Health
KEY1:F3. THIS ENTRY DESCRIBES PART 1 OF A TWO PART KIT. SEE THIS SAME
NSN, P/N IND B, FOR PART 2 DATA.

HCC:F3
Boiling Pt:B.P. Text:175 TO 320F
Vapor Density:> AIR

Stability Indicator/Materials to Avoid:YES
Hazardous Decomposition Products:FUMES MAY CONTAIN CARBON MONOXIDE &
OXIDES OF NITROGEN.MAY PRODUCE HZD FUMES WHEN HEATED TO
DECOMPOSITION AS IN WELDING.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.